my cav turbo 4x4 work in progress
my cav turbo 4x4 work in progress
my cav has been off the road a few week now, and it getting a bit of a make over during the winter months, it wont be back on the roads until next spring, some pics of the work so far,
boot floor all cleaned and repainted
started to build my boot install, this is still to finish and wire up
next i removed the front seats so i could pull the carpet back to check the inner sills and floor
only rust i found was the small patch of surface rust seen in the fist pic, this has now been sorted
removed the front strut lower arm etc, and re undersealed the inner wing area
then decide to change all the running gear from red to yellow (some people might think it looks crap, but it looks nice and clean).
renewed lower arms, ball joint and drop links at the same time, track rod ends to be changed next, only took pics of one side, but
other side is the same.
fittrd xe inlet cam to give engine a bit more torque
bought a few bits of bling for the engine bay
vernier pulleys
chrome tank for power steering fluid
engine loom cover
3"" tophat
and dip stick and breather tube
and i also got this boost gauge fitted into the steering cowling,
thats all for now, but ive got loads more planned to do, and a few more parts to aquire,
post pics as i progress
thanks for looking Ads
boot floor all cleaned and repainted
started to build my boot install, this is still to finish and wire up
next i removed the front seats so i could pull the carpet back to check the inner sills and floor
only rust i found was the small patch of surface rust seen in the fist pic, this has now been sorted
removed the front strut lower arm etc, and re undersealed the inner wing area
then decide to change all the running gear from red to yellow (some people might think it looks crap, but it looks nice and clean).
renewed lower arms, ball joint and drop links at the same time, track rod ends to be changed next, only took pics of one side, but
other side is the same.
fittrd xe inlet cam to give engine a bit more torque
bought a few bits of bling for the engine bay
vernier pulleys
chrome tank for power steering fluid
engine loom cover
3"" tophat
and dip stick and breather tube
and i also got this boost gauge fitted into the steering cowling,
thats all for now, but ive got loads more planned to do, and a few more parts to aquire,
post pics as i progress
thanks for looking Ads
Re: my cav turbo 4x4 work in progress
Looking good matey!
i'm liking the boot build, wouldn't mind doing one of them myself really
i'm liking the boot build, wouldn't mind doing one of them myself really
Re: my cav turbo 4x4 work in progress
thanks Dan, are you novadose on ctor, im Ads, i bought a leather interior off you a year or so back, out of your white cav turbo, Ads
- humbucker
- Club Admin
- Posts: 9298
- Joined: Tue Aug 19, 2008 10:42 pm
- Location: Cobra Kai Dojo
- Contact:
Re: my cav turbo 4x4 work in progress
nice one cyril, think i saw that steering cowl on some for sale thread or another a while back, really good, does it get in the way of your temp gauge or any other readings?
Re: my cav turbo 4x4 work in progress
dont really know mate, as i havnt fitted it yet, im planning on putting a new dash in over the winter, so a waste of time fitting the boost gauge till its done.. Adsilovemyelite wrote:nice one cyril, think i saw that steering cowl on some for sale thread or another a while back, really good, does it get in the way of your temp gauge or any other readings?
Re: my cav turbo 4x4 work in progress
Quite like the yellow on the struts
Re: my cav turbo 4x4 work in progress
turboads wrote:thanks Dan, are you novadose on ctor, im Ads, i bought a leather interior off you a year or so back, out of your white cav turbo, Ads
Yep thats me
back with yet again another turbo lol I'll keep one one day.
Re: my cav turbo 4x4 work in progress
well the tubby has been back on the road a few months now, i have had a few issues with it (head gasket failiure, leaking core plug) but all sorted now, a few up to date pics
thanks for looking. Ads
thanks for looking. Ads
Re: my cav turbo 4x4 work in progress
Looking really smart,like under the bonnet,well done mate,worth all the hard work.
William
William
PRESENT CAR;1995(N) Vauxhall Cavalier GLS, 2.0 litre, 16 Valve Automatic in Smoke Grey.
Owned since August 2006
Owned since August 2006
Re: my cav turbo 4x4 work in progress
looking good ads and yellow looks fine , nice to see a couple of tubbys getting some tlc
now running a swedish vauxhall...
the old cav vid
http://www.youtube.com/watch?v=YYC4wHjqAhw
the new saab vid
http://www.youtube.com/watch?v=h-K5L6UDGFk
the old cav vid
http://www.youtube.com/watch?v=YYC4wHjqAhw
the new saab vid
http://www.youtube.com/watch?v=h-K5L6UDGFk
- humbucker
- Club Admin
- Posts: 9298
- Joined: Tue Aug 19, 2008 10:42 pm
- Location: Cobra Kai Dojo
- Contact:
Re: my cav turbo 4x4 work in progress
very smart
Re: my cav turbo 4x4 work in progress
well got my tubby back together last week, and ive benn racking up a few miles in it, i forgot how good it was to drive, seems to be running well (proberbly break down now ive said that LOL) heres a couple of recent pics
not the best pics as took with phone,
while its been off the road its had a new alloy rad, new intercooler, fuel pressure reg, chrome distributor, new injectors, new plugs, dizzy cap and rotor fitted
not the best pics as took with phone,
while its been off the road its had a new alloy rad, new intercooler, fuel pressure reg, chrome distributor, new injectors, new plugs, dizzy cap and rotor fitted
- Lowrider Dave
- Club Admin
- Posts: 2993
- Joined: Wed Dec 22, 2010 10:00 am
- Location: Southampton
- Contact:
Re: my cav turbo 4x4 work in progress
Very nice! Love the stance - how low is that?
Re: my cav turbo 4x4 work in progress
Very nice mate looks cool on the black turbo rims!
Re: my cav turbo 4x4 work in progress
40mm alround mate, Adslowrider dave wrote:Very nice! Love the stance - how low is that?
- Lowrider Dave
- Club Admin
- Posts: 2993
- Joined: Wed Dec 22, 2010 10:00 am
- Location: Southampton
- Contact:
Re: my cav turbo 4x4 work in progress
turboads wrote:40mm alround mate, Adslowrider dave wrote:Very nice! Love the stance - how low is that?
Re: my cav turbo 4x4 work in progress
Hi all, i havnt even seen the cav for about 5 weeks, as its locked away, but ive been getting a few parts to fit when i get to se it,
polished belt cover
a 3 gauge plate that fits into radio cage, ive got a volts gauge in now, but ive ordered a oil pressure and a oil temp gauge to go in, this will be fitted in the top radio din hole, with the radio in the bottm one
a singlr gauge pod for my boost gauge, this will be on top of the dash to the right of the steering wheel
and a walbro 255 fuel pump
hope to get these fitted sometime.
polished belt cover
a 3 gauge plate that fits into radio cage, ive got a volts gauge in now, but ive ordered a oil pressure and a oil temp gauge to go in, this will be fitted in the top radio din hole, with the radio in the bottm one
a singlr gauge pod for my boost gauge, this will be on top of the dash to the right of the steering wheel
and a walbro 255 fuel pump
hope to get these fitted sometime.
- humbucker
- Club Admin
- Posts: 9298
- Joined: Tue Aug 19, 2008 10:42 pm
- Location: Cobra Kai Dojo
- Contact:
Re: my cav turbo 4x4 work in progress
im not a huge fan of the silver/grey cavaliers tbh but the combination of the black wheels really brings it to life. love this pic:
- Envoy CDX
- Club Admin
- Posts: 9696
- Joined: Sun Sep 23, 2007 3:51 pm
- Location: Jarrow, Newcastle Upon Tyne
Re: my cav turbo 4x4 work in progress
Smoke grey is a cracking colour for a Cavhumbucker wrote:im not a huge fan of the silver/grey cavaliers tbh but the combination of the black wheels really brings it to life. love this pic:
- humbucker
- Club Admin
- Posts: 9298
- Joined: Tue Aug 19, 2008 10:42 pm
- Location: Cobra Kai Dojo
- Contact:
Re: my cav turbo 4x4 work in progress
Thought you might say that!Envoy CDX wrote:Smoke grey is a cracking colour for a Cav
Re: my cav turbo 4x4 work in progress
thanks for the comments on the cav, its now back on the road, all legal with tax test and insurance, went straight throuh test without a single advisory, even passed the emmissions no bother, got a few new parts to fit before total vauxhall live, walbro uprated fuel pump, reconditioned turbo, trumpet dump valve, polished cam belt cover, etc, etc, i will post pics as i am doing the work, Ads
Re: my cav turbo 4x4 work in progress
ook all the required nipples and hoses off the old turbo, and fitted to my nrewly aquired reconditioned turbo,
ready to now fit onto cav.
ready to now fit onto cav.
- humbucker
- Club Admin
- Posts: 9298
- Joined: Tue Aug 19, 2008 10:42 pm
- Location: Cobra Kai Dojo
- Contact:
Re: my cav turbo 4x4 work in progress
progress!